1、鋰電池Pack容量一致性原則

1C電流恒流充電至3.65V，轉3.65V恒電壓充電，電流降為0.03Cs時停止。以1C電流放電，直到放電終止電壓2.0V，放電答量不低于額(e)定容量95%。

2、鋰電池Pack恒流比原則

以1C恒流放電至2.0V，再以1C電流恒流充電至3.65V，轉3.65V恒電壓充電，電流降為0.03C時停止，恒流充入的電量與充入總電量之比，充電恒流比不小于93%。

3、鋰電池Pack放電平臺要求

電池滿電后，以1C電流恒流放電至2.0V，記錄電壓到3.1V的時間。放電平臺不少于48分

4、鋰電池Pack自放電要求

①滿電55℃士2℃的環境下貯存7d。②滿電25±5℃的環境下貯存28d。③不帶電45℃±2℃10天，測電壓。④不帶電25土5℃30天，測電壓。

荷電保持率不少于95%。開路電壓不小于2.80V。

5、鋰電池Pack內阻要求：電芯內阻間誤差小于5mΩ；

6、鋰電池Pack電芯之間電壓差小于5mV;

7、鋰電池Pack電芯之間一致性越高越好；

8、鋰電池Pack電芯的循環壽命

①同批次材料、同一工藝、同一設備、同一時間生產的同型號電池可以組裝到同一電池組。②45土2℃環境下1C充放電，循環200次后，不少于初始1C5容量的95%。③品質部每批電池抽檢5只樣品進行測試，作為配當依據。

45士2℃環境下1C充放電，循環300次后，不少于初始1C；容量的95%。

鋰電池Pack的成組原則為：使用同一個檔欠的電芯組裝，當某一批次該檔次的電芯數量不夠時，使用相鄰批次同檔電壓同檔容量的電芯補足缺額。嚴禁不同電壓、不同內阻檔次電芯用于同一電池組的組裝。